24-VOLTAIR
TESTIMONIALS
“The 12-Voltair compressor is the best tool I have purchased for my harvest operation in years. I used it everyday for the whole 2005 season. The ability to have air anytime and without having to start a gas engine was great. This unit was easy to install and takes up very little space. I would recommend this product to anyone who needs air on a daily basis. This is a great product.”
FEATURES
MOTOR- High torque, 1800 rpm, permanent magnet motor with brushes and thermal protection. NOTE: This is not a starter or series wound motor.
PUMP- Heavy duty twin cylinder, cast iron pump, oil lubed compressor
DRIVE SYSTEM- Positive timing gear belt pulley system. This type of pulley system eliminates belt slippage and extends the life of our belt.
ENCLOSURE - All Steel Powder Coated 18 gauge enclosure.
FULL 1 YEAR WARRANTY
SPECIFICATIONS
POWER SOURCE- 24-VDC
AMP DRAW- 40 amps
DUTY CYCLE- 80% - 8 out of 10 minute runtime @ Temps under 90 Degrees F.
MAX PSI- 150 psi
CFM** @ 50 psi 12 scfm
CFM** @ 100 psi 6 scfm
THERMAL PROTECTOR- Our thermal protector will shut down the 24-Voltair when the motor exterior case reaches 200F. This is a auto-reset thermal protector that will reset itself within 20 minutes.
OIL CAPACITY- 2 cups
OIL RECOMMENDATIONS
-20F - 70F use a 10W non detergent compressor oil
50F - 110F use a 30W non detergent compressor oil
-20F - 110F use a 40W synthetic non detergent compressor oil
** SCFM is a number that can often be misleading. The 24-Voltair is capable of filling a 10 gallon air tank from 0-150psi in just 3 minutes.
LINKS
- Owner’s Manual (PDF)
- FAQ (PDF)
- Troubleshooting Guide (PDF)
- Wire Diagram (PDF)
Battery facts
1. The OEM (Original Equipment Battery) that came with the purchase of your vehicle is only designed to keep up with the demand of the vehicle. For optimum performance, Voltair recommends replacing your battery with a battery that is rated with 120 or more minutes of reserve.
2. The alternator that comes standard in most vehicles will charge between 40-50 amps at a vehicle idle. Since the Voltair draws 80 amps when in use, Voltair recommends a good battery and in some cases a second battery may be necessary.
3. Voltair recommends a battery with 120 or more minutes of reserve. The 12-Voltair air compressor does not need cranking amps for optimum performance, but it does need battery reserve.
4. Over time a battery’s ability to hold a full charge greatly diminishes. A lead battery may need to be replaced every 2 years and an optima battery may need to be replaced every 4 years.
5. If you are using or planning to use the 12-Voltair for more than 3-4 hours on a day-to-day basis adding a second battery will help in achieving optimum performance